Electric Mr. Pea Sheller / Bean Sheller

• Saves Hours of Tedious Work.
• Shells 1.5 - 3 Bushels in an Hour!

MR. Peas Sheller is gentle as hand shelled but FAST!  EFFORTLESS!  Model # 800-M

New intermediate size sheller for all garden fresh peas or beans.  Shells black eye, Purple hull, small Crowder, Cream peas, English peas, and HARD TO SHELL lima and butter beans.  A real work saver and a pleasure to use.  Very silent operation.  No adjustments to make.  Light enough to use in any convenient place. 
Shells an honest 1 1/2 to 3 bushels per hour.  Fully assembled and ready to use.  One year guarantee.

Long life 1/15 horse power, 115 volt motor.  Improved roller design, steel gears, brass bearings, die cast pulleys, sturdy belt, half-gallon container, best grade unfinished plywood frame construction.  Almost half the cost of a small commercial Sheller but does about as well.

TO USE- first wash the produce.  Then, load tray and simply feed hull ends into rollers.  Peas and beans fall into pan.  Lima and butter beans should be fed through at an angle with the thick vine end first.  It may be helpful to pull some hulls on through rollers carefully from time to time.  SATISFACTION GUARANTEED! 

Operating Instructions for the Electric Mr. Pea Sheller

Peas or beans should be ripe ( as for hand shelling ) before they are ready for the machine shelling.  They should be fully developed and of sufficient size with the pea or edible portion about 1/4" or larger for best results.  Peas that are too green or that have been allowed to dry very hard will present a problem.

Peas that have been gathered green and out in the refrigerator will be a problem unless allowed to come to room temperature and dry out a little.

Avoid feeding vines or other foreign objects through rollers.  If motor fails, to start when cord is plugged in (there is no on off switch) give large pulley a gentle push in clockwise direction, and be careful!

To clean machine unplug electrical cord and wash off rollers and tray.

To lubricate the machine, unplug the electrical cord.  Place a few drops of oil over the two screws holding the steel bearing support frames into place.  Tilt machine and turn pulley by hand to allow oil to reach all brass bearing surfaces.  Apply light grease to gears occasionally.

Apply a few drops of oil in each of the two holes in the motor about twice a year.

Belt should be loose, do not tighten the belt or use another belt other that that provided with your sheller.

The motor is thermally protected and will shut off in case of over heating.  Should this happen, disconnect cord and allow motor to cool.  Automatic reset in motor will let it start again when it is cool.  Do not substitute a heavier duty motor for the one provided. 

The Best Pea and Bean Shelling Ideas We Know

Beans and peas that just will not shell without mashing probably have either very tough pods due to growing conditions, or may be too green or too dry.  These may be shelled very easily by using the following method:

The peas or beans, in the pod, are blanched in boiling water from one to four minutes.  Cool quickly in cold water.  Now feed them through your MR.
Pea Sheller's special rollers.  The results will please you.

This process makes the pods or hulls tender enough that even the thin skin around the peas or beans are not damaged, and you can shell them very quickly.

One minute blanching will usually soften the toughest of pods so that shelling is now easy.  If you are preparing the produce for your freezer, then blanch the peas or beans four minutes and freeze after shelling.

Warning:

1:  Avoid getting your fingers too close to rollers.

2:  Do not unplug cord if your hands are wet.  Let the machine keep on running until your hands are dried.  Likewise, should the motor stall due to too many peas or beans being fed through at once, it will not hurt the motor to stay on while you dry your hands.

3:  Always store in a dry place and treat as any other electrical appliance.

 As far as I can see this is the lowest price on the INTERNET.
 you can not get this for less this is the only electric pea sheller made look around and buy here will ship in 1 business day guarantee by manufacture for 1 year.....others shipping may be cheaper but the total price to you is lower....

Item number:250459748371


this is my new ebay account where you can still get this for $204.00+ shipping!!!!!

Sorry the abouv is not correct I do not have this for $ 112,00 this is an error Still 205 is the cheepest on the internet including ebay.

 i am selling this for $204.00 with 12 shipping please look at item # 250475867081
or search sell4less903 on ebay search

 please see my other auction item # 250481787881 for a discounted shipping charge limited time only.......
I just started the ebay id sell4less903 so the biz there will be welcome

 please look at this search sell4less903 my new ebay buy it there cheeper!@